Safety Warning
DIY auto repair can cause serious injury, fire, or vehicle damage. These guides are for informational purposes only. Always follow OEM torque specs, wear PPE, and consult a certified mechanic if you are unsure. You are solely responsible for your safety.
SYS.OK|MANUAL.DB● LIVE
HOMESERVICE MANUALSTOYOTA2025HIGHLANDER HYBRID XLEREPAIR AND DIAGNOSIS (SINGLE PAGE)ENGINE PERFORMANCETESTING & DIAGNOSISENGINE CONTROL SYSTEM (A25A-FXS) - DIAGNOSTIC CODES (P05B1-06DA)SFI SYSTEMDTC P0627-13: FUEL PUMP "A" CONTROL CIRCUIT OPEN; DTC P12D0-13: FUEL PUMP CONTROL (ALL PHASE) CIRCUIT OPEN; DTC P12D1-13: FUEL PUMP CONTROL (U PHASE) CIRCUIT OPEN; DTC P12D2-13: FUEL PUMP CONTROL (V PHASE) CIRCUIT OPEN; DTC P12D3-13: FUEL PUMP CONTROL (W PHASE) CIRCUIT OPEN [11/2024 - ]DESCRIPTION
2025 Toyota Highlander Hybrid XLE
DTC P0627-13: Fuel Pump "A" Control Circuit Open; DTC P12D0-13: Fuel Pump Control (All Phase) Circuit Open; DTC P12D1-13: Fuel Pump Control (U Phase) Circuit Open; DTC P12D2-13: Fuel Pump Control (V Phase) Circuit Open; DTC P12D3-13: Fuel Pump Control (W Phase) Circuit Open [11/2024 - ]: Description
2025 Toyota Highlander Hybrid XLESECTION Description
Refer to DTC P025A-12.
Refer to DESCRIPTION
| DTC No. | Detection Item | DTC Detection Condition | Trouble Area | MIL | Memory | Note |
|---|---|---|---|---|---|---|
| P0627-13 | Fuel Pump "A" Control Circuit Open | When the fuel pump control ECU operation duty ratio is 3 to 65%, an open is detected in the FPU, FPV and FPW circuit for 3 seconds or more (2 trip detection logic). |
|
Comes on | DTC stored |
|
| P12D0-13 | Fuel Pump Control (All Phase) Circuit Open | When the fuel pump control ECU operation duty ratio is 3 to 65%, an open is detected in the FPU, FPV and FPW circuit for 3 seconds or more (1 trip detection logic). |
|
Does not come on | DTC stored |
|
| P12D1-13 | Fuel Pump Control (U Phase) Circuit Open | When the fuel pump control ECU operation duty ratio is 3 to 65%, an open is detected in the FPU circuit for 3 seconds or more (2 trip detection logic: except Mexico models, 1 trip detection logic: for Mexico models). |
|
|
DTC stored |
|
| P12D2-13 | Fuel Pump Control (V Phase) Circuit Open | When the fuel pump control ECU operation duty ratio is 3 to 65%, an open is detected in the FPV circuit for 3 seconds or more (2 trip detection logic: except Mexico models, 1 trip detection logic: for Mexico models). |
|
|
DTC stored |
|
| P12D3-13 | Fuel Pump Control (W Phase) Circuit Open | When the fuel pump control ECU operation duty ratio is 3 to 65%, an open is detected in the FPW circuit for 3 seconds or more (2 trip detection logic: except Mexico models, 1 trip detection logic: for Mexico models). |
|
|
DTC stored |
|
RELATED DATA LIST
| DTC No. | Data List |
|---|---|
| P0627-13 P12D0-13 P12D1-13 P12D2-13 P12D3-13 |
Fuel Pump Control Duty Ratio |
RENDER: 1.0x
NO RELATED
Recommended Tools & Savings
Use the Manual With the Right Hardware
Pair factory procedures with proven DIY tools so the instructions are easier to execute.
Affiliate disclosure: We may earn a commission at no extra cost to you.
When to See a Mechanic
Stop DIY work and contact a certified mechanic immediately if any of the following apply:
- • You smell fuel, burning insulation, or see smoke.
- • Brakes feel soft, pull hard to one side, or make grinding noises.
- • The engine overheats, stalls repeatedly, or misfires under load.
- • You are missing required tools, torque specs, or safe lifting equipment.
- • You are not confident in the next step or safety outcome.