Safety Warning
DIY auto repair can cause serious injury, fire, or vehicle damage. These guides are for informational purposes only. Always follow OEM torque specs, wear PPE, and consult a certified mechanic if you are unsure. You are solely responsible for your safety.
SYS.OK|MANUAL.DB● LIVE
HOMESERVICE MANUALSOLDSMOBILE2004BRAVADA AWDREPAIR AND DIAGNOSISEXTERNAL PAGESDIFFERENT CARSECTION 490 (COMMON SPECS & PROCEDURES)AIR CONDITIONINGMANUAL SYSTEMHVAC TORQUE SPECIFICATIONS
2004 Oldsmobile Bravada AWD
HVAC Torque Specifications
2004 Oldsmobile Bravada AWDSECTION HVAC Torque Specifications
WARNING: This page is about a different car, the 2003 Saturn Vue. However, it is still accessible from the selected car via links, so may be relevant.
HVAC TORQUE SPECIFICATIONS
| Application | Ft. Lbs. (N.m) |
|---|---|
| Battery Box-To-Body Bolt | 11 (15) |
| Compressor Clutch Nut | 14 (19) |
| Compressor Hose Assembly-To-Compressor Bolt | 20 (27) |
| Compressor Hose Assembly-To-Condenser Nut | 12 (16) |
| Compressor Hose Assembly-To-TXV Nut (2.2L) | 12 (16) |
| Compressor-To-Engine Block Bolt | 16 (22) |
| Discharge Line Nut | 12 (16) |
| Evaporator Outlet Hose-To-Compressor Hose Nut (2.2L) | 12 (16) |
| Evaporator Outlet Hose-To-TXV Nut (2.2L) | 12 (16) |
| Liquid Line-To-TXV Nut | 12 (16) |
| Liquid Line-To-Receiver Dehydrator Nut | 12 (16) |
| Receiver Dehydrator to Condenser Nut | 12 (16) |
| INCH Lbs. (N.m) | |
| Actuator-To-HVAC Case Screw | 9 (1) |
| Air Inlet Assembly Screw | 9 (1) |
| Air Outlet Duct Screw | 9 (1) |
| Blower Motor Resistor Screw | 9 (1) |
| Blower Motor Screw | 9 (1) |
| Compressor Hose Assembly-To-Battery Box Nut (2.2L) | 71 (8) |
| Compressor Pressure Relief Valve | 89 (10) |
| Compressor Thermal Protection Switch Retainer Bolt | 53 (6) |
| CRFM Bracket Bolt | 89 (10) |
| Defrost Actuator-To-Evaporator Case Screw | 9 (1) |
| Defroster Duct -To-HVAC Module Nut | 22 (2.5) |
| Evaporator Case Assembly to Blower Case Assembly Screw | 9 (1) |
| Evaporator Cover Screw | 9 (1) |
| Evaporator Outlet Hose-To-Air Cleaner Bracket Bolt (2.2L) | 62 (7) |
| Evaporator Outlet Hose-To-Cowl Nut (2.2L) | 71 (8) |
| Evaporator Pipe Cover Screw | 9 (1) |
| Floor Actuator-To-Evaporator Case Screw | 9 (1) |
| Front Of Dash-To-HVAC Module Seal Nut | 70 (8) |
| Heater Core Cover Screw | 9 (1) |
| Heater Core Pipe Cover Screw | 9 (1) |
| Heater Core Screw | 9 (1) |
| Heater Duct-To-Heater Core Cover Screw | 18 (2) |
| Hold Down Bracket & Bolt | 53 (6) |
| HVAC Controller-To-Radio Bezel Screw | 22 (2.5) |
| HVAC Module-To-Cross Car Beam Nut/Bolt | 70 (8) |
| Intermediate Duct Fastener | 22 (2.5) |
| Liquid Line-To-Strut Tower Nut (2.2L) | 44 (5) |
| Liquid Line-To-Strut Tower Nut (2.2L) | 89 (10) |
| Metal Bracket-To-HVAC Module Screws | 18 (2) |
| Panel Actuator-To-Evaporator Case Screw | 9 (1) |
| Passenger Compartment Air Filter Housing Nut | 80 (9) |
| Receiver Dehydrator Bracket Bolt-To-Body | 89 (10) |
| Recirc Assembly Screw | 9 (1) |
| Refrigerant Low Temperature Sensor Bolt-To-TXV | 45 (5) |
| Refrigerant Pressure Sensor-To-Compressor Hose Assembly | 89 (10) |
| Temperature Cable Screw | 9 (1) |
| TXV Backing Plate Bolt | 80 (9) |
RENDER: 1.0x
NO RELATED
Recommended Tools & Savings
Use the Manual With the Right Hardware
Pair factory procedures with proven DIY tools so the instructions are easier to execute.
Affiliate disclosure: We may earn a commission at no extra cost to you.
When to See a Mechanic
Stop DIY work and contact a certified mechanic immediately if any of the following apply:
- • You smell fuel, burning insulation, or see smoke.
- • Brakes feel soft, pull hard to one side, or make grinding noises.
- • The engine overheats, stalls repeatedly, or misfires under load.
- • You are missing required tools, torque specs, or safe lifting equipment.
- • You are not confident in the next step or safety outcome.