Safety Warning
DIY auto repair can cause serious injury, fire, or vehicle damage. These guides are for informational purposes only. Always follow OEM torque specs, wear PPE, and consult a certified mechanic if you are unsure. You are solely responsible for your safety.
SYS.OK|MANUAL.DB● LIVE
HOMESERVICE MANUALSFORD1999ECONOLINE E150 1/2 TON V6-4.2L VIN 2REPAIR AND DIAGNOSISPOWERTRAIN MANAGEMENTTECHNICAL SERVICE BULLETINS
1999 Ford Econoline E150 1/2 Ton V6-4.2L VIN 2
Powertrain Management: Technical Service Bulletins
1999 Ford Econoline E150 1/2 Ton V6-4.2L VIN 2SECTION Technical Service Bulletins
- Recalls
- Customer Interest
- Fuel Pump - Whine Heard Through Radio Speakers
- Audio System - Whining/Buzzing Noise From Speakers
- Engine Controls - Engine Surge/Rolling Idle/DTC's Set
- Engine - Lean Driveability Symptoms
- Emissions - MIL ON/DTC's Stored/Check Fuel Cap Lamp ON
- Speedometer Defective,, 4X4 Lamp ON, DTCs P1635/P1639
- A/T - 4R70W TCIL ON/Code P0782/Delayed/No 2-3 Upshift
- A/T - 4R70W TCIL/MIL ON/Trouble Codes Stored
- EGR Valve - MIL ON/DTC's P0306 Set/Hesitation
- Restraints - Air Bag Lamp ON/DTC's B1876/B1880/B1920
- Engine - Spark Knock on Light Load/Acceleration
- By Symptom
- Customer Interest
- Fuel Pump - Whine Heard Through Radio Speakers
- Audio System - Whining/Buzzing Noise From Speakers
- Engine Controls - Engine Surge/Rolling Idle/DTC's Set
- Engine - Lean Driveability Symptoms
- Emissions - MIL ON/DTC's Stored/Check Fuel Cap Lamp ON
- Speedometer Defective,, 4X4 Lamp ON, DTCs P1635/P1639
- A/T - 4R70W TCIL ON/Code P0782/Delayed/No 2-3 Upshift
- A/T - 4R70W TCIL/MIL ON/Trouble Codes Stored
- EGR Valve - MIL ON/DTC's P0306 Set/Hesitation
- Restraints - Air Bag Lamp ON/DTC's B1876/B1880/B1920
- Engine - Spark Knock on Light Load/Acceleration
- Driveability
- False instrument warning light/gauges
- Inoperative
- Leaks
- Loose
- No shift/Incorrect gear engagement
- Noise
- Recalls
- Slipping
- Customer Interest
- All Technical Service Bulletins
- Driveability - Vacuum Leak Detection
- Fuel Pump - Whine Heard Through Radio Speakers
- Audio System - Whining/Buzzing Noise From Speakers
- Engine Controls - Engine Surge/Rolling Idle/DTC's Set
- PCM - Reprogramming Out of Vehicle
- Emissions/Engine Controls - Driveability Diagnosis
- Engine Controls - Bi-Fuel O2 Sensor Diagnostics
- Engine - Lean Driveability Symptoms
- Ignition System - Coil-On-Plug Misfire Diagnostic Tips
- Engine Controls - General PCM Programming Procedures
- Recall - Cracked Fuel Tanks, Incorrect VIN's Listed
- Recall 01V114000: Possible Fuel Tank Crack
- EVAP - DTC's P0442/P0455/MIL ON/No Driveability Concerns
- Emissions - MIL ON/DTC's Stored/Check Fuel Cap Lamp ON
- Speedometer Defective,, 4X4 Lamp ON, DTCs P1635/P1639
- PCM - Calibration Information
- A/T - 4R70W TCIL ON/Code P0782/Delayed/No 2-3 Upshift
- A/T - 4R70W TCIL/MIL ON/Trouble Codes Stored
- EGR Valve - MIL ON/DTC's P0306 Set/Hesitation
- Fuel Economy - Customer Expectation vs. Vehicle Usage
- Locks - Lock Service Packages Available
- Fuel - Volatility Related Driveability Concerns
- Bi-Fuel - Lock Off Solenoid/Tank Valve Coil Resistance
- Restraints - Air Bag Lamp ON/DTC's B1876/B1880/B1920
- Engine - Spark Knock on Light Load/Acceleration
RENDER: 1.0x
NO RELATED
Recommended Tools & Savings
Use the Manual With the Right Hardware
Pair factory procedures with proven DIY tools so the instructions are easier to execute.
Affiliate disclosure: We may earn a commission at no extra cost to you.
When to See a Mechanic
Stop DIY work and contact a certified mechanic immediately if any of the following apply:
- • You smell fuel, burning insulation, or see smoke.
- • Brakes feel soft, pull hard to one side, or make grinding noises.
- • The engine overheats, stalls repeatedly, or misfires under load.
- • You are missing required tools, torque specs, or safe lifting equipment.
- • You are not confident in the next step or safety outcome.