Safety Warning
DIY auto repair can cause serious injury, fire, or vehicle damage. These guides are for informational purposes only. Always follow OEM torque specs, wear PPE, and consult a certified mechanic if you are unsure. You are solely responsible for your safety.
SYS.OK|MANUAL.DB● LIVE
HOMESERVICE MANUALSCHEVROLET2009TAHOE 4WD V8-6.0L HYBRIDREPAIR AND DIAGNOSISHYBRID DRIVE SYSTEMSPOWER CONTROL SYSTEMDRIVE MOTOR CONTROL MODULELOCATIONS
2009 Chevrolet Tahoe 4WD V8-6.0L Hybrid
Drive Motor Control Module: Locations
2009 Chevrolet Tahoe 4WD V8-6.0L HybridSECTION Locations
Passenger Compartment/Roof Component Views
Drive Motor Battery Components
1 - Battery Case Upper Cover Assembly
2 - Battery Upper Cover Nut
3 - Bar Code Label
4 - Battery Danger Label
5 - Drive Motor Battery Case Upper Cover Bolt
6 - Battery Side Cover Nut
7 - Drive Motor Battery Right Side Cover
8 - Drive Motor Battery Side Cover Bolt
9 - Battery Caution Label
10 - Drive Motor Battery Cable Assembly Nut
11 - Drive Motor Battery Positive Relay Cable Assembly
12 - Drive Motor Battery Current Sensor Assembly
13 - Drive Motor Generator Battery Current Sensor Bracket
14 - Drive Motor Battery Current Sensor Bolt
15 - Drive Motor Generator Battery Control Module Assembly
16 - Drive Motor Battery Control Module Bracket
17 - Drive Motor Battery Control Module Bracket Bolt
18 - Battery Cable Clip
19 - Drive Motor Battery Control Module Bracket Bolt
20 - Drive Motor Battery Control Module Bracket
21 - Drive Motor Battery Positive and Negative Cable Bolt
22 - Drive Motor Battery Positive and Negative Cable Assembly
23 - Battery Front Cover Retainer
24 - Drive Motor Battery Front Cover Assembly
25 - Drive Motor Battery Front Cover Bolt
26 - Battery Terminal Cover
27 - Battery Terminal Cover
28 - Battery Terminal Cover
29 - Drive Motor Battery Cooling Air Outlet Duct Seal
30 - Drive Motor Battery with Case
31 - Drive Motor Battery Cooling Air Outlet Duct Seal
32 - Drive Motor Battery Current Limit Resistor Nut
33 - Drive Motor Battery Inverter Current Limit Resistor
34 - Drive Motor Battery Cable Terminal Nut
35 - Drive Motor Battery Positive High Voltage Contactor Relay Assembly
36 - Drive Motor Battery Wire Harness Connector Retainer
37 - Drive Motor Battery Power Inverter Current Limit Relay Assembly
38 - Drive Motor Battery Positive High Voltage Contactor Relay Nut
39 - Drive Motor Battery Positive Relay Nut
40 - Drive Motor Generator Battery Positive Relay Insulator Nut
41 - Drive Motor Generator Battery Positive Relay Insulator Assembly
42 - Drive Motor Battery Sensor Bracket Bolt
43 - Drive Motor Battery Cable Terminal Extension Cover
44 - Drive Motor Battery Terminal Block Cover Nut
45 - Drive Motor Battery Terminal Extension Cable Bolt
46 - Drive Motor Battery Terminal Block Nut
47 - Drive Motor Battery Cable Terminal Extension
48 - Drive Motor Battery High Voltage Manual Disconnect Knob Housing
49 - Drive Motor Battery Cover Terminal Bolt
50 - Battery Cable Terminal Retainer
51 - Drive Motor Battery High Voltage Manual Disconnect Lever Assembly
52 - Drive Motor Battery Disconnect Switch Nut
53 - Battery Disconnect Switch Cable Assembly
54 - Drive Motor Battery Cable Nut
55 - Battery Positive and Negative Cable Cover
56 - Drive Motor Battery Cooling Air Outlet Duct Seal
57 - Drive Motor Generator Battery Ground Bolt
58 - Drive Motor Generator Battery Mounting Nut
59 - Battery Terminal Cover
60 - Battery Terminal Cover
61 - Drive Motor Battery Rear Cover Bolt
62 - Drive Motor Battery Rear Cover Assembly
63 - Drive Motor Generator Battery Ground Nut
64 - Drive Motor Battery Cooling Air Outlet Duct Seal
65 - Drive Motor Generator Battery Retainer Nut
66 - Drive Motor Generator Battery Negative Relay Bracket Nut
67 - Drive Motor Generator Battery Negative Relay Bracket
68 - Drive Motor Battery Negative Relay Bracket Bolt
69 - Drive Motor Battery Negative High Voltage Contactor Relay Assembly
70 - Drive Motor Battery Negative Relay Cable Assembly
71 - Drive Motor Battery Cable Assembly Nut
72 - Drive Motor Battery Cable Terminal Nut
73 - Drive Motor Battery Housing Relay Nut
Front of Vehicle/Engine Compartment Component Views
Hybrid Control Electronic Component Views
1 - Drive Motor Generator Control Module Assembly
2 - Accessory DC Power Control Module
3 - Drive Motor Generator Power Inverter Module
4 - Hybrid Powertrain Control Module (HPCM)
5 - Motor Control Module (MCM) 1, Motor Control Module (MCM) 2
6 - Sight Shield Circuit Breaker
7 - Drive Motor Generator Power Inverter Module 3 Phase Cable Assembly
8 - Drive Motor Battery 300 Volt Positive and Negative Cable Assembly
9 - Drive Motor with Generator Assembly -1st Position
10 - Drive Motor with Generator Assembly -2nd Position
11 - Drive Motor Generator Battery
12 - Drive Motor Generator Battery Control Module
13 - Drive Motor Battery Cable Terminal Extension Cover
14 - Transmission Power Inverter Module (3 Phase) Cable Cover
15 - Automatic Transmission Auxiliary Fluid Pump Control Module
16 - Automatic Transmission Auxiliary Fluid Pump Assembly
17 - A/C Compressor
Engine Compartment - Right Hand Side (HP2)
1 - Drive Motor Generator Power Inverter Module Cover
2 - Electronic Power Steering Motor Control Module
3 - A/C Compressor
4 - Heater Coolant Pump
5 - Accessory DC Power Control Module
6 - Drive Motor Generator Power Inverter Module
Engine Compartment - Left Front (HP2)
1 - Fuse Block - Underhood
2 - Fuse Block - Auxiliary (HP2)
3 - Engine Control Module (ECM) (HP2)
4 - Battery Current Sensor (HP2)
RENDER: 1.0x
NO RELATED
Recommended Tools & Savings
Use the Manual With the Right Hardware
Pair factory procedures with proven DIY tools so the instructions are easier to execute.
Affiliate disclosure: We may earn a commission at no extra cost to you.
When to See a Mechanic
Stop DIY work and contact a certified mechanic immediately if any of the following apply:
- • You smell fuel, burning insulation, or see smoke.
- • Brakes feel soft, pull hard to one side, or make grinding noises.
- • The engine overheats, stalls repeatedly, or misfires under load.
- • You are missing required tools, torque specs, or safe lifting equipment.
- • You are not confident in the next step or safety outcome.