Safety Warning
DIY auto repair can cause serious injury, fire, or vehicle damage. These guides are for informational purposes only. Always follow OEM torque specs, wear PPE, and consult a certified mechanic if you are unsure. You are solely responsible for your safety.
SYS.OK|MANUAL.DB● LIVE
1984 Chevrolet Corvette V8-350 5.7L
Repair and Diagnosis: Technical Service Bulletins
1984 Chevrolet Corvette V8-350 5.7LSECTION Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Recall - P/S Pump Pulley Replacement
- Recall 85V118000: Rear Differential Defect
- Recall - Differential Cross Shaft Retention Kit
- Recall - Front Brake Caliper Bracket Bolt Replacement
- Recall 83V064000: Caliper Bracket Mounting Bolt Defect
- Recall 83V081000: Battery Cable Insulation Wears Through
- Recall - Cruise Control System Modification
- Recall 91V143000: Seat Belt Retractor Defect
- Recall 86V056000: Headlight Switch Defect
- Recall 85V029000: Speed Control Defect
- Customer Interest
- Interior - Eliminating Unwanted Odors in Vehicles
- Body - Broken Rear Window Defogger Grid Detection
- Audio System - Noise When Using Portable Playback Unit
- Tires/Wheels - Vibration Shortly After Tires Are Mounted on Rim
- Power Steering - Fluid Leaks Due to Extreme Low Temps
- Restraints - Seat Belt Latching Issues/Warning Lights
- A/C - Musty Odors Emitted From (HVAC) System
- Electrical - MIL ON/DTC's Set By Various Control Modules
- Fuel System - Factors That Affect Economy/Mileage
- Dash Board - Cleaning of Upper Panel Surfaces
- Engine - Stops When Starting With A/C ON
- A/C - No Heat Condition
- A/C - Loss of Cooling
- Cooling System - Leaks
- Engine - Overheating During Hard Driving Conditions
- A/T - Intermittent Slip, Downshift, or Busy Cycling TCC
- Generator/P/S Pump - Moaning Noise At Idle With A/C ON
- Brake Pads - Hold-Down Spring Breakage
- Disc Brakes - Squealing Noise
- Rear Spindle - Snapping Noise
- Power Steering - Lack of Assist
- Rocker Cover - Oil Leaks
- Muffler - Paint Peeling
- Engine Oil Cooler - Oil Leaks
- Engine - Loss of Engine Oil Pressure After Oil Change
- Wheels - Air Leak, Cast Aluminim Wheel Porosity
- Tires - Uneven Wear-Outer Ribs
- Door Locks - Binding or Sticking or Key Hard to Insert
- Windows - Will Not Close
- Power Seat - Inoperative/Blown Fuse
- Power Seat Adjuster - Excessive Movement
- Half-Shaft and Propshaft - Clinking Noise
- A/T - Oil Pan Leaks
- A/T - New Pump to Case Bolt and O-Ring Improves Sealing
- Oil Pump Body Seal - Fluid Leaks
- A/T - Replacement of the Pump Body Oil Seal Assembly
- A/T - Vent Pipe Oil Leak
- A/T - Oil Exhausting Out the Breather
- A/T - Burned Clutches/Cracked Turbine Shaft
- Radio - Ticking Noise
- Engine - Low Speed Surge
- Engine - Surge After a Hot Soak
- Rear Hatch Defogger - Blows Fuses
- Electric Outside Rear View Mirrors - Inoperative
- Instruments - Door Ajar Light Inoperative
- Radio - Popping Noise From Speakers
- Audio - Poor AM or FM Radio Reception
- Oil Filters (Small 75 mm) - Leakage Prevention
- Brakes - Poor Rotor Finish/Hard Pedal Feel
- A/C - R12 Loss From Loose or Missing Access Fitting Caps
- Engine - Noise
- Engine - Miss, Hesitation, or Roughness
- Brakes - Light Brake Drag While Driving
- Wipers - Intermittent Operation
- A/C - Refrigerant Hose & Clamp Repairs
- Side Door - Lateral Movement With The Window Down
- Door Trim Panel - Loose
- Body/Interior - Squeaks and Rattles
- Overview
- Squeaks and Rattles Instrument Panel - Driver's Side
- Squeaks and Rattles Center of Instrument Panel
- Squeaks and Rattles Instrument Panel - Passenger's Side
- Squeaks and Rattles Forward of Instrument Panel
- Squeaks and Rattles Doors
- Squeaks and Rattles Console Area
- Squeaks and Rattles Roof
- Squeaks and Rattles Center of Rear Compartment
- Rear Lift Window - Hard to Open/Hinge Loose to Glass
- Outside Rear View Mirror - Loss of Adjustment
- Front Center Air Deflector - Damaged
- Wheels - Wire Wheel Cover Noisy At Low Speeds
- Wire Wheel Cover - Snapping/Creaking Noise
- A/T - Slipping/Loss of Drive Range
- A/T - THM 700-R4 Slips In Reverse
- A/T - Shudder in Reverse Condition
- A/T - Buzzing Noise at Idle
- M/T - Noise With Automatic Overdrive Disengaged
- M/T - Neutral/Drive Gear Rattle
- Compact Disc Players - CD Changer Loading Procedures
- SIR - Operating Vehicle with Warning Light On
- Fuel - Rusting Filler Door Hinge Links/Pins
- Instrument Panel - Upper Surface Reflection
- Fuels - Effect of Volatility on Driveability
- Engine - High/Rough or Unstable Idle
- Transparent Removable Roof Panel - Breakage
- Paint - Repair Procedure Without Repainting
- Carpet Inserts - Loose
- A/T - 4L60 Binding/Inoperative In Reverse
- A/T - Harsh 1st to 2nd Gear Upshift
- A/T - Partial Tie Up In reverse
- A/T - 4L60/700-R4 Transmissions Stuck In First
- Underhood Lamps - Inoperative or Stay On
- Turn Signal Lever - Rattles
- M/T - Loss of Overdrive Operation
- P/S - Reduced Assist When Cold
- Power Steering - Reduced Assist At Low Temperatures
- Brakes, Front - Pulsation Diagnosis, Correction, Repair
- Fuel - No Start, Driveability, Excessive Alcohol Content
- A/T - Grinding Noise In All Ranges/No Drive Condition
- Engine, A/T - Shift/Driveability Concerns/MIL ON
- A/T - No Movement in Drive or 3rd Gear
- Body - Marks/Stains on Windshield When Wet
- Body - Stain/Film On Windshield Glass Perimeter
- Tires/Wheels - Low Tire/Leaking Cast Aluminum Wheels
- Electrical - Intermittent MIL/DTC P2138/Reduced Power
- Recommended Repairs
- Seals, Gaskets
- Superceded Bulletins
- 10-00-89-010A - 10/19/12
- 12-06-01-008 - 09/01/12
- 04-06-01-029F - 09/01/12
- 05-06-04-022H - 07/18/12
- 04-06-04-047J - 07/18/12
- 00-03-10-006G - 07/17/12
- 03-03-10-007F - 07/12/12
- 01-08-51-003A - 11/01/2010
- 01-08-51-003 - 01/01/2010
- 08-07-30-035A - 01/01/2010
- 05-06-04-022F - 10/01/10
- 06-08-64-001 - 12/01/06
- 06-08-64-001A - 10/01/09
- 05-03-08-002 - 12/01/05
- 05-03-08-002A - 10/19/08
- 05-03-08-002B - 10/01/09
- 06-00-89-051B - 12/01/08
- 04-08-50-006 - 06/01/04
- 04-08-50-006A - 12/01/07
- 00-06-01-012A - 02/08/05
- 933E106 - 07/01/93
- 93966C - 10/01/93
- 932633E - 07/01/93
- 932549A - 07/01/93
- 9310159 - 02/01/93
- 93-6-107 - 07/01/97
- 926102 - 10/01/95
- 922816C - 09/01/92
- 91576E - 08/01/90
- 913117 - 03/01/94
- 912083B - 03/01/94
- 903165 - 08/01/90
- 9018769 - 03/01/90
- 892717A - 10/01/89
- 891785 - 06/01/89
- 891726 - 06/01/89
- 87121 - 05/01/87
- 86-60 - 12/01/86
- 83-I-115 - 09/01/83
- 631208 - 04/01/97
- 420515 - 12/01/94
- 40-05-01C - 10/01/99
- 310503B - 01/12/96
- 23-62-03 - 07/01/97
- 12-92-43 - 07/01/97
- Warranty - Expediting parts
- Warranty - Parts Returning Program
- Overview
- Requests, Reminders and Debits
- Part Preparation For Shipping
- Warranty Core Parts
- Hazardous Material
- Tires
- Campaign Parts and Special Parts Return Request
- Repair Order Only Requests
- Forms WPC006 and WPC005
- Return and Method of Reimbursement
- Dealer Feedback
- Part Return Request Example
- Request For Part Return/Repair Order Only/Remind. Example
- Request For Repair Order Only Example
- Reminders Only Example
- Warranty - Expediting Parts
- Parts - Expediting Information
- Warranty - Personal Property Damage
- Electrical - Diode Replacement Information
- Wipers/Washers - Windshield Wiper Maintenance/Cleaning
- Wipers - Performance/Cleaning Instructions/Maintenance
- Windshield Wipers - Performance/Cleaning and Maintenance
- Glass/Body - Windshield Wiper Performance
- Body - Distortion On Outer Glass Surfaces
- Lighting - Headlamp Polycarbonate Lens Damage Prevention
- Lighting - Lamp Polycarbonate Lens Damage Prevention
- Odometer/Speedometer - Repair Facilities
- Body - Paint-Less Dent Repair Recommendations
- Body - Application of Anti-Corrosion Materials
- Body - Metal Body Panel Corrosion Protection
- Body - Hem Flange Sealer For Corrosion Protection
- Body - Metal Body Panel Corrosion Protection
- Body - Metal Panel Corrosion Protection
- Body - Hem Flange Repair
- Body - Paint-less Dent Repair Process
- Weatherstrips - Use of Silicone Grease for Maintenance
- Interior - Seat Cover Wrinkle/Crease/Burn Info
- Interior - Seat Cover Wrinkle/Crease/Crack/Burn Info.
- Locks - Key Code Security Rules And Information
- Locks - Key Code Securtiy Rules And Information
- Locks - Binding/Sticking Door Lock Cylinders
- Body - Exterior Emblem Discoloration/Blistering/Peeling
- Body - Vehicle Glass Distortion Information
- Body - Side Window Chipping Information
- Body - Use of Silicone for Weatherstrip Maintenance
- Body - TPO Fascia Cleaning Prior to Painting
- Audio System - Noise When Using Portable Playback Unit
- Audio System -Noise When Using Portable Playback Unit
- Policy - Procedure to Handle Customer Radio Concerns
- Audio - Radio Frequency Interference (RFI) Diagnosis
- Cellular Phones - Operating Characteristics
- Restraints - Availability of Seat Belt Extenders
- Restraints - Seat Belt Warning Lamp On/Buckling Issues
- Restraints - Seat Belt Warning Lamp On/Buckling Issues
- Restraints - Seat Belt Operating Characteristic
- Seat Belts - Seat Belt Extender Availability
- Restraints - Driver/Passenger Seat Head Rest Information
- Restraints - Driver/Passenger Seat Head Rest Information
- Restraints - Passenger Presence System Information
- Airbags - Disconnect Procedures
- A/C - Broken Rear Window Defogger Grid Detection
- Interior - Elimination Of Unwanted Odors
- Interior - Elimination Of Unwanted Odors
- Interior, A/C - Vehicle Odor Elimination
- Tools - A/C Leak Detector Kit Maintenance
- Interior - Eliminating Unwanted Odors
- Suspension - Shock Absorber/Strut Fluid Leak Information
- Suspension - Shock Absorber/Strut Leakage Information
- Power Steering - Noise
- Steering - Spool Valve Split Rings
- Electrical - Information For Electrical Ground Repair
- Electrical - Information For Electrical Ground Repair
- Electrical - Information For Electrical Ground Repair
- Electrical - Information For Electrical Ground Repair
- Audio System - Portable Audio Equipment Noise
- Locks - KeyCode Security Rules and Information
- Locks - Key Code Security Rules and Information
- Locks - Key Code Security Rules and Information (CANADA)
- Drivetrain - Clunk Noise Shifting From PARK Into Gear
- A/T - DEXRON(R)-VI Fluid Information
- Drivetrain - Clunk Noise Shifting From PARK Into Gear
- Drivetrain - Driveline Clunk Information
- Manual Transmission - M/T Operating Characteristics
- M/T - Operating Characteristics
- M/T - Operating Characteristics of Manual Transmissions
- M/T - Normal Operating Characteristics
- Drivetrain - Axle Lubricant Recommended
- A/T - Clunk When Shifting From PARK/DRIVE/REVERSE
- Automatic Transmission - Service Procedure Change
- A/T - Service Procedure
- A/T - Fluid Oil Cooler Flush
- A/T - Fluid Oil Cooler Flush
- Automatic Transmission - Fluid Cooler Flushing
- A/T - Oil Cooler Flushing and Flow Check Procedures
- A/T - Oil Cooler Flushing/Flow Check
- A/T - 2-3 Upshift or 3-2 Downshift Clunk Noise
- A/T - Slipping, Loss of Drive Range Condition
- Fuel System 'TOP TIER' Detergent Gasoline Information
- Fuel System - GM Fuel System Treatment PLUS(R) Info.
- Fuel System - 'TOP TIER' Detergent Gasoline Information
- Fuel System - TOP TIER Detergent Gasoline (Canada)
- Fuel System - TOP TIER Gasoline Usage (Canada)
- Fuel System - TOP TIER Detergent Gasoline Usage
- Fuel System - TOP TIER Detergent Gasoline
- Fuel System - GM Fuel System Treatment Plus(R)
- Fuel System - TOP TIER Gasoline Information (Canada)
- Fuel System - TOP TIER Gasoline Information
- Fuel System - E85 Fuel Usage Information
- Fuel System - Fuel System Treatment PLUS(R)
- Engine Controls - Aftermarket Accessory Usage
- Engine Controls - Aftermarket Accessory Usage
- Engine Controls - Aftermarket Accessory Usage
- Cooling System - Approved Coolant Recycling Processes
- A/C - Servicing of Aluminum Heater Cores/Radiators
- A/C - Aluminum Heater Core and/or Radiator Replacements
- Vehicle - Engine Crankcase and Subsystems Flushing Info.
- Vehicle - Engine Crankcase and Subsystems Flushing Info.
- Vehicle - Engine/Subsystem Flushing Recommendations
- Engine - Use of 'Surface Conditioning Disks'
- Engine - Crankcase Flushing Information
- Engine - Sealant Usage/procedures
- Engine - Surface Conditioning Disc Usage Prohibition
- Engine - Sealant Usage Recommendations
- Gasket Surfaces - Use of Surface Conditioning Discs
- Oil - Normal Oil Consumption
- Engine - Intake Manifold Inspection/Replacement
- Intake Manifold - Inspect/Replace After Engine Damage
- Engine/Fuel - Additive Information
- Manual Transmission - Operating Characteristics
- Fuel System - Fuel Injector Maintenance Cleaning
- Engine Coolant - Approved Recycle Systems
- Wheels, Aluminum - Clear Coat Scratch Removal
- Chrome Wheels - Chemical Staining Precautions
- Aluminum Wheel - Refinishing Recommendations
- Chrome Wheels - Chemical Staining
- Aluminum Wheels - Low Tire Pressure Condition
- Wheels/Tires - Slow Leaks From Aluminum Wheels
- Wheels - Aluminum Wheel Refinishing Recommendations
- Tires - Puncture Repair Procedure
- A/T - Fluid Cooler Flushing
- Coolant - Current Information on Propylene Glycol Blend
- Coolant - Use of Propylene Glycol Based Blend
- Engine Coolant - Information
- Cooling System - DEX-COOL(R) Coolant Usage Information
- Cooling System - DEX-COOL(R) Coolant Information
- A/T - DEXRON III(R) (H-Revision) Specification Upgrade
- A/T - DEXRON(R) VI Fluid Availability
- Tires/Wheels - Low Tire Pressure With Aluminum Wheels
- Tires/Wheels - Nitrogen Gas Usage for Filling Tires
- Engine - Unnecessary Flushing Services
- Wheels Chrome Wheel Chemical Staining/Pitting/Corrosion
- Wheels - Changing Procedures/Precautions
- Wheels - Pitting/Brake Dust On Chrome Wheels
- Tires - Original Equipment Tire Characteristics
- Tires - Inflation Pressure Information
- Tires - Tread Puncture Repair Procedures
- Tires - Radial Force Variation (RFV) Information
- Wheel Alignment - Recommendations/Requirements
- Tires - Proper Tire Pressure Information
- Tires - Proper Inflation Pressure Information
- A/T - DEXRON-VI(R) Fluid Availability
- Wheels/Tires - 'Upsized' Wheel And Tire Information
- Tires - Proper Inflation Pressure Info.
- Engine - Noise Damage Caused By The Oil Filter
- Engine - Internal Noise/Damage After Oil Filter Change
- Tires - Information on Proper Tire Pressure
- Wheel/Tire - Upsized Wheel/Tire Performance Info.
- Tires/Wheels - Vibration/Balance/Shake/Flat Spotting
- Tires/Wheels - Tire Inflation Pressure Information
- Tires - (RFV) Radial Force Variation Information
- Tires - Tire Puncture Repair Procedures
- Tires - Nitrogen Gas Usage
- Wheels/Tires - Changing Tire and Wheel Assemblies
- Wheels/Tires -Low Tire Pressure
- Engine - Accessory Drive Belt Noise Diagnostics/Tool
- Wheels/Tires - Accessory Wheel/Tire Mounting/Balancing
- Wheels/Tires - Chrome or Chrome Plated Steel Valve Caps
- Alignment - Specifications/Requirements/Recommendations
- Tires - Radial Force Variation (RFV) Info.
- Tire - Use Of Nitrogen Gas In Tires
- Tires - Correct Inflation Pressure Information
- Wheels/Tires - Original Equipment Characteristics
- Wheels/Tires - Tire Puncture Repair Procedures
- Wheels/Tires - Low Tire Pressure
- Wheels/Tires - OE Tire/Wheel Characteristics
- Wheels/Tires - Low Tire Pressure/Aluminum Wheels Leak
- Wheel - Refinishing Aluminum Wheels
- Tires - Tire Radial Force Variation (RFV)
- Wheels - Chrome Wheel Staining/Pitting/Corrosion
- Wheels/Tires - Use of Nitrogen Gas in Tires
- Wheels/Tires - Tire Radial Force Variation (RFV)
- Engine - GM Dexos 1(R) and Dexos 2(R) Oil Specifications
- Wheels - Chrome Wheel Staining/Pitting/Corrosion
- Tires/Wheels - Information on Tire Radial Force Variation (RFV)
- All Technical Service Bulletins
- Interior - Eliminating Unwanted Odors in Vehicles
- Locks - Key Code Security Rules, Key Code Look Up
- Vehicle - Engine And Sub Systems Flushing Info. (CANADA)
- Vehicle - Engine And Sub-Systems Flushing Recommendations
- Wheels/Tires - Use Of Nitrogen Gas In Tires
- Tires - Information On Proper Tire Pressure
- Engine - THIS BULLETIN HAS BEEN CANCELED
- Fuel System - TOP TIER Detergent Gasoline
- Tires/Wheels - OE Tire Shake/Vibration Information
- Suspension - Shock Absorber/Strut Fluid Leak Information
- M/T - Operating Characteristics Information
- Brakes - Resurfacing Park Brake Portion of Rear Brake Rotor
- Body - Hem Flange Sealer For Corrosion Protection
- Engine - Intake Manifold Inspection/Replacement
- Body - Metal Body Panel Corrosion Protection
- Fuel System - GM Fuel System Treatment PLUS(R) Info.
- Body - Broken Rear Window Defogger Grid Detection
- Fuel System - Fuel Injector Maintenance Cleaning
- Audio - Inadvertent Steering Wheel Button Activation
- Audio System - Noise When Using Portable Playback Unit
- Tires/Wheels - Vibration Shortly After Tires Are Mounted on Rim
- A/T - Fluid Oil Cooler Flow Test
- Power Steering - Fluid Leaks Due to Extreme Low Temps
- Lighting - Lamp Polycarbonate Lens Damage Prevention
- Restraints - Seat Belt Latching Issues/Warning Lights
- Body - Side Window Chipping Information
- Restraints - Driver/Passenger Seat Head Rest Information
- Engine - Use of 'Surface Conditioning Disks'
- Body - Application of Anti-Corrosion Materials
- A/T - 2-3 Upshift or 3-2 Downshift Clunk Noise
- A/C - Musty Odors Emitted From (HVAC) System
- A/T - Slight Vehicle Movement In Park At Start Up
- A/T - DEXRON(R)-VI Fluid Information
- Wheels/Tires - Refinishing Aluminum Wheels
- Lighting - Exterior Lamp Condensation and Replacement
- Electrical - MIL ON/DTC's Set By Various Control Modules
- Steering/Suspension - Wheel Alignment Specifications
- Warranty - Claims Submission
- Warranty - Goodwrench Service Lifetime Service Guarantee
- Warranty - GM Dealer Parts Procurement
- Warranty - Notice of Delayed Start Process
- Warranty - Parts Warranty Special Claims B and C
- Warranty - Request for Wholesale Authorization
- VIN Plate - Replacement Policy and Procedure
- Warranty - GM Dealer Empowerment Program
- Labor - Revised Operation Z1241/Personal Property Damage
- Warranty - Repair/Replace Policies & Procedures
- Parts Expediting - Reimbursement Policy
- Warranty - Enhanced Sublet Repair Policy
- Warranty - Required Claim Submission Procedures
- Warranty - Repair and Claims Procedures
- Overview
- Certified Dealer Service Management empower./repair approval
- Customer Satisfaction
- Dealer Repair Options
- Coverage Guidelines/GM Certified Used Vehicle Coverage
- Warranty Coverage - Cause of Failure
- GM Certified Used Vehicle Warranty Verification
- Warranty Administration
- Courtesy Transportation
- Campaigns
- Dealer Reimbursement Guidelines (Warranty Claims Submission)
- Customer Reimbursements
- Warranty Repairs on Used Vehicles In Inventory
- Reconditioning
- Inspection and Warranty Repairs
- Buy-Back Vehicles
- Diesel Engine Repairs/Deductible
- Corrosion Protection and Emissions Warranties
- U.S. Touring Owner Service
- Warranty - Claim Processing
- Warranty - Corporate Parts Return Program Instructions
- Vehicle - Use of a Diagnostic Worksheet
- Vehicle - AC Delco Locator Service, Electronics Exchange
- Warranty - Diagnostic Claim Processing Revisions
- Service Option Label - Information
- Electrical - Wiring Repair Temp Range Precaution
- Campaign - Product Bulletin Numbering System
- Passenger Car and Truck - Identification
- Overview
- Vehicle Identification Number
- Body Identification Plate
- 1984-85 Service Parts Identification Label Locations
- Passenger Car Engine Production Code Explanation
- Truck Engine Production Code Explanation
- Transaxle Assembly Identification Information
- Passenger Car Transmission Production Code Explanation
- Truck Transmission Production Code Explanation
- Passenger Car Rear Axle Identification
- Light Duty Truck Rear Axle Identification
- Light Duty Truck Four Wheel Drive Front Axle Identification
- Vehicle - Current Model Line Designators
- Parts - Expediting Procedures
- Glass - Adhesive Caulking Kit Revisions
- Warranty - Corporate Parts Return Program
- I/M 240 Repairs - Obtaining Technical Assistance
- Fuel System - Factors That Affect Economy/Mileage
- Dash Board - Cleaning of Upper Panel Surfaces
- Electrical - Instrument Panel And General Wiring Repair
- A/C - CFC Reduction & Refrigerant Recovery Recycling
- A/C Refrigerant - Contamination
- Engine - Stops When Starting With A/C ON
- Tools - A/C Leak Detector Maintenance Kit Availability
- A/C - Systems With R12 Or R134a Service Issue
- A/C - Retrofitting R-12 to R-134a
- A/C - Tool And Equipment Maintenance
- A/C - PureGuard 2 Operating Alert
- A/C - No Heat Condition
- A/C - Loss of Cooling
- A/T & M/T - AC Delco Remanufactured Transmissions
- ACDelco(R) Remanufactured Transmissions - Program Update
- RTV Sealer and Gasket Eliminator - Usage
- Engines - ACDelco Remanufactured
- Engine - Surface Conditioning Discs Precautions
- Engine - AC Delco Remanufactured Engines
- Cooling System - Leaks
- Engine - Overheating During Hard Driving Conditions
- A/T - Intermittent Slip, Downshift, or Busy Cycling TCC
- Throttle Position Sensor - Specifications
- Steering - System Bleed Procedures
- Generator/P/S Pump - Moaning Noise At Idle With A/C ON
- Recall - P/S Pump Pulley Replacement
- Fuel - Pump Replacement Caution, Strainer
- Brake Pads - Hold-Down Spring Breakage
- Disc Brakes - Squealing Noise
- Brake Pad - New Pad Material
- A/C - Compressor Assembly Availability
- A/C - System Diagnostic Procedure
- Suspension - Shock Absorber/Strut Replacement Guidlines
- Rear Spindle - Snapping Noise
- Steering Gear - Revised Intermediate Shaft Torques
- Steering - Rack and Pinion Short Gear Availability
- Power Steering - Lack of Assist
- Engine - Revised Camshaft Lift Specifications
- Rocker Cover - Oil Leaks
- Cooling - Radiator Repair/Replacement Guidelines
- Muffler - Paint Peeling
- Engine - Revised Intake Manifold Installation
- Engine Oil Cooler - Oil Leaks
- Engine - Loss of Engine Oil Pressure After Oil Change
- Brakes - Manual Clarified, Caliper To Knuckle Clearance
- Wheels - Air Leak, Cast Aluminim Wheel Porosity
- Aluminum Wheels - Cleaning/Painting/Coating
- Wheels (Steel) - Damage Due to Improper Mounting
- Wheels - Installation of After Market Styled Wheels
- Wheels - Sealing Leaking Cast Aluminum
- Wheels - Procedure For Removing Tight Fitting Wheels
- Aluminum Wheels - Scuff/Scratch Removal
- Warranty - OE Chrome Plated Aluminum Wheel ID
- Wheels - Locking Wheel Nuts Impact On Tire Balance
- Power Steering Fluid Cooler - Service Installation Kit
- Tires - Uneven Wear-Outer Ribs
- Tires - Ride Harshness
- Tires - Speed Rated Information
- Stabilizer Bar Link Attaching Nut - New Type
- Door Locks - Binding or Sticking or Key Hard to Insert
- Lock Cylinders - Inoperative/Proper Lubricant Usage
- Windows - Will Not Close
- Window Regulator - Replacement
- Window Regulators - Replacement
- Power Window Regulator - Warranty Extension
- Power Seat - Inoperative/Blown Fuse
- Seat Cushion - Retainer Wire Service Kit
- Seats - Six-Way Power Adjusters
- Power Seat Adjuster - Excessive Movement
- Spare Tire - Temporary Use Spares
- Half-Shaft and Propshaft - Clinking Noise
- A/T - Oil Pan Leaks
- A/T - Updated Side Cover Or Bottom Pan Removal
- Differential Pinion Shaft Lock Screw - Service
- Rear Axle Service Parts Usage and Identification
- Recall 85V118000: Rear Differential Defect
- Recall - Differential Cross Shaft Retention Kit
- A/T - New Pump to Case Bolt and O-Ring Improves Sealing
- Oil Pump Body Seal - Fluid Leaks
- A/T - Updated Oil Pump Assemblies
- A/T - Replacement of the Pump Body Oil Seal Assembly
- A/T - Vent Pipe Oil Leak
- A/T - Oil Exhausting Out the Breather
- A/T - New Pump Assembly Service Parts Information
- A/T - Oil Pump Rotor and Slide Service Procedure
- A/T - Burned Clutches/Cracked Turbine Shaft
- A/T - 700R4 Updated Oil Pump
- A/T - 700R4 Front Pump Air Check
- A/T - 2004R/700R4 Oil Pump & Slide Service
- A/T - 700R4 Pump Assembly Casting Number Information
- MAP - Revised Check Chart for DTC's 33, 34, 63, 64
- Flywheel Bolts - Revised Torque Specification
- A/T - 700R4 Model/Converter Identification
- A/T - TV Cable Identification (700-R4 Light Duty)
- Fuel Injectors - Remanufactured for TBI Systems
- Tools - Introduction Of The Fuel Injector Tester
- ECM - Revised Replacement Procedure
- Engine Controls - ECM May Contain Wrong PROM
- ECM/PCM - Damaged and/or Misdiagnosed
- ECM - Knock Retard Data Stream Changes
- ECM - Packard 32 Way Connector Identification
- Oxygen Sensors - Silica Contamination
- Recall - Front Brake Caliper Bracket Bolt Replacement
- Recall 83V064000: Caliper Bracket Mounting Bolt Defect
- Battery - Parasitic Current Drain Diagnosis
- Battery - Dead/No Crank After Overnight Set
- Battery - Diagnosis and Charging
- Battery - Parasitic Draw Test
- Warranty - New Vehicle/Replacement Battery
- Battery - Insulator Replacement & Caution
- Battery - Add On Electrical Equipment, Side Terminals
- Recall 83V081000: Battery Cable Insulation Wears Through
- Radio - Ticking Noise
- Engine - Low Speed Surge
- Engine - Surge After a Hot Soak
- Fuel - Feed/Return Pipe Repair
- Fuel - Line O Rings Precaution
- Power Antenna Mast - Lubrication
- Rear Hatch Defogger - Blows Fuses
- Electric Outside Rear View Mirrors - Inoperative
- Instruments - Door Ajar Light Inoperative
- Recall - Cruise Control System Modification
- Headlamp Door Actuator - Service Kit
- Audio - Radio Frequency Interference (RFI) Diagnosis/ID
- Radio - Popping Noise From Speakers
- Radios/Electronics - Static Electricity Damage
- Audio - Poor AM or FM Radio Reception
- Seat Belts - Extender Availability
- Recall 91V143000: Seat Belt Retractor Defect
- Lap/Shoulder Belts - Dealer Installed Rear Kits
- IP Dimmer Control - Proper Setting
- Oil Filters (Small 75 mm) - Leakage Prevention
- Brakes - Poor Rotor Finish/Hard Pedal Feel
- Brakes - Pulsations and Rotor Surface Refinish
- Brakes - Change In Brake Feel After Rotor Refinishing
- Brakes - On-Car Rotor Turning Tool
- Brakes - Rotor & Hub Flange Cleaning Tool Revision
- A/C - Refrigerant Loss Prevention
- A/C - R12 Loss From Loose or Missing Access Fitting Caps
- Engine - Noise
- Engine - Miss, Hesitation, or Roughness
- HEI System - Description and Diagnosis Chart
- A/T - Sporadic Engagement of Torque Converter Clutch
- Odometer/Speedometer - ACDelco Service Center Locations
- Recall 86V056000: Headlight Switch Defect
- Brakes - Light Brake Drag While Driving
- Wipers - Intermittent Operation
- A/C - Refrigerant Hose & Clamp Repairs
- A/C Compressor Shaft Seal - Usage
- Brake System - Service Information
- Anti-Lock Brake - Aftermarket Products Usage Precaution
- Body - Revised Repair Materials
- Body - Sealer Tape For Collision Repairs
- Paint - Plastic Media Blasting Sources
- Roof Panel Attaching Plate - Repair
- Fiber Glass Body Panel - Painting Procedures
- Vehicle - Add On Equipment Precaution
- Aftermarket Accessories - Installation Guidelines
- State Emissions Testing Information
- Enhanced IM240 Program - Implementation Plan
- Emission - Enhanced Inspection Maintenance Programs
- I/M 240 Program - Equipment Purchase
- I/M Emissions Diagnostic Manual -Program
- Enhanced Emission I/M - Program Update
- Enhanced Emission Inspection Maintenance - Equipment
- Engine Controls - Electrostatic Discharge Damage
- Fuel System - Integrator/Block Learn Operation
- Oxygen Sensor Test - Revised Tech 1 Mass Storage CD
- Side Door - Lateral Movement With The Window Down
- Rear Hatch Window Assist Rod - Design Change
- Door - Trim Panel Upper Garnish Molding Availability
- Door Trim Panel - Loose
- Body/Interior - Squeaks and Rattles
- Overview
- Squeaks and Rattles Instrument Panel - Driver's Side
- Squeaks and Rattles Center of Instrument Panel
- Squeaks and Rattles Instrument Panel - Passenger's Side
- Squeaks and Rattles Forward of Instrument Panel
- Squeaks and Rattles Doors
- Squeaks and Rattles Console Area
- Squeaks and Rattles Roof
- Squeaks and Rattles Center of Rear Compartment
- Windows - Rear Hatch Trim Panel/Rubber Bumper
- Convertible Top - Cleaning and Care of Fabric
- Child Seat - Top Strap Anchor Installation
- Child Restraint - Auxiliary Seat Belt
- Windshield - Two-Part Urethane Adhesive For Installation
- Wiper Blades - Chatter/Uneven Wipe
- Wiper Blades - Chattering on Windshield
- Rear Lift Window - Hard to Open/Hinge Loose to Glass
- Outside Rear View Mirror - Loss of Adjustment
- Body - Upper Quarter Panel Removal and Installation
- Front Center Air Deflector - Damaged
- Engine - Oil Recommendations
- Maintenance - Updated Minimum Acceptable Oil Levels
- Cooling System - Reconstituted Anti-Freeze Information
- Coolant - Information on Propylene Glycol Usage
- Warranty - Recycled Engine Coolant Policy
- Cooling System - Use of Recycled Engine Coolant
- Coolant - Used Anti-Freeze Policy
- P/S - Rack & Pinion O-Ring Seal Fitting Leaks
- Wheels - Wire Wheel Cover Noisy At Low Speeds
- Wire Wheel Cover - Snapping/Creaking Noise
- A/T - Burned 3-4 Clutch and/or High 2-3 Shifts
- A/T - New Case Assembly, Removal of Pressure Taps
- A/T - Slipping/Loss of Drive Range
- A/T - Forward Clutch Plate Assembly Modifications
- A/T - THM 700-R4 Slips In Reverse
- A/T - 700R4 New Lo & Reverse Clutch Assembly
- A/T - 700R4 New 3-4 Clutch Apply Package
- A/T - Service Replacement Model Update
- A/T - Shudder in Reverse Condition
- A/T - Understanding Identification Information
- A/T - Identification Information
- A/T - Buzzing Noise at Idle
- A/T - Core Return Product Feedback Form
- A/T - Control Valve Without Throttle Valve Sleeve Update
- A/T - 700R4 Updated Input Shaft/Pump/Converter
- A/T - 700R4 Solenoid Reference Chart
- A/T - 2004R/700R4 Pump Assembly
- A/T - 700R4 2nd Apply Piston & Housing Applications
- A/T - 700R4 Updated Pinion Carrier
- A/T - 700R4 Service Update
- A/T - 700R4 Oil Pressure Switch Locations
- A/T - 700R4 Harsh 1-2 Shift
- A/T - 700R4 Shudder In Reverse
- A/T - THM 7700R4 Correction To Service Bulletin - 8614
- A/T - Overheating In Fourth Gear
- A/T - 700R4 1984 Production Changes
- A/T - 700R4 Checking Lubrication Passages
- A/T - 700R4 Down-Shift Clunk In Manual 3 Range
- A/T - 700R4 Auxiliary Accumulator Valve
- A/T - 700R4 Correction To Bulletin SIL8722
- A/T - 700R4 Fluid Leaks/Oil Pump Body Seal
- A/T - Converter Clutch Solenoid Fluid Source I.D.
- A/T - 700R4 & 2004R New Iron Pump Rings
- A/T - 700R4 New Control Valve Assembly
- A/T - 700-R4 & 400 Improved Governor Driven Gear
- A/T - ATRASIL8713 Service Bulletin Correction
- A/T - Torque Converter Identification
- A/T - Harsh Reverse Engagements
- A/T - Engine Vacuum Testing
- A/T - Bind-Up On The 1-2 or 3-2 Downshift
- A/T - 700R4 No 4th, Late 4th, Falls Out Of 4th
- A/T - Diagnosing Converter Lock-Up Problems
- Overview
- Test # 1 - Checking For 12 Volts at Terminal -A-
- Test # 2 - Checking For 12 Volts Across Fuse
- Test # 3 - Checking For 12 Volts Across Brake Switch
- Test # 4 - Adjusting/Replacing the Brake Switch
- Test # 5 - Checking Wires For Shorts and Opens
- Test # 6 - Checking For Ground at Terminal -D-
- Test # 7 - Grounding the -D- Wire
- Test # 8 - Checking Cooler Line Pressure or Surge
- Test # 9 - Checking the Solenoid
- Test # 10 - Checking Electrical Switches on Trans.
- Test # 11 - Checking Lockup Apply Valve
- Test # 12 - Checking Signal Oil Circuit
- Test # 13 - Checking the Computer
- A/T - Valve Body Assembly 700-R4 Inspection
- A/T - How To Use A Pressure Gauge
- A/T - 700R4 Valve Body Interchange
- A/T - 700R4 Bind In Reverse After Rebuild
- A/T - 200/200C/200R4, 325/3254L, 700-R4 No 2nd Gear
- A/T - THM Late or No Upshifts
- A/T - 700R4 Shifts In Manual Low
- A/T - 700R4, 2004R No Line Pressure Rise
- A/T - 700R4 Forward Sprag Design
- A/T - 700R4 Rear Planet Failure/Lack of Lube
- A/T - 700R4 No 2nd, No 4th and No TCC
- A/T - Drive Axle and Wheel Lug Nut Torque Specifications
- A/T - Delayed Forward Engagement/Burnt 3-4 Clutches
- A/T - 700R4 Pump Cover Screen
- A/T - 700R4 Erratic/Late Shifts As Unit Gets Hot
- A/T - 700R4 No Upshift, Good Reverse and Drive
- A/T - Occasional No-Reverse, Or Shudder In Reverse
- A/T - 700R4 Sleeving Governor Bore
- A/T - No Drive/Reverse/Third Gear Or Fourth Gear
- A/T - No Converter Clutch Apply When Unit Is Hot
- A/T - 700R4 No-Reverse, Shudder, Or Delayed Reverse
- A/T - Recurrent Sticking Valves/In Line Filters
- A/T - 700R4 Valve Chatter/Not Enough Oil Feed
- A/T - 200C/2004R, 700-R4 Lip Seal Packages Part Numbers
- A/T - Rapid Converter Pump Bushing Wear
- A/T - 2004R & 700R4 Pump Break Up
- A/T - Converter Clutch Shudder
- A/T - 700R4 TCC Lock-Up Kit Precautions
- A/T - 125, 200C/200 4R, 700 R4 Hidden Residue Build Up
- A/T - 200 4R & 700 R4 Pump Failure
- A/T - 700R4 Late Upshifts/High Main Line Pressure
- A/T - 700R4 Low Mainline Oil Pressure
- A/T - 700R4 Snap Ring Jumps Out of Place
- A/T - Sticking Throttle Valves
- A/T - 700R4 Passing Gear Spin-Up/Engine Revs Up
- A/T - 700R4 Manual Valve Sticks
- A/T - 700R4 Reverse Friction (Lined) Clutches
- A/T - Pressure Tap Locations
- A/T - Blows Fuses, Engine Runs Poorly, No TCC Lock-Up
- A/T - Partial Tie Up In Reverse
- A/T - 700R4 Case Switches Installed On Outside Of Case
- A/T - 700R4 Diagnosing Internal Pressure Leaks
- A/T - 700R4 Clunk On 2-3 Gear Shift
- A/T - 700R4 Updated Input Sprag Assembly
- A/T - 700R4 4-3 Downshift On Slight Acceleration
- A/T - Methods to Check for Restricted Exhaust
- A/T - Slipping or No-Shift/Metal Sealing Rings
- A/T - Front Bushing Wear
- A/T - 2-3 Flare-up, or Repeated 3-4 Clutch Failure
- A/T - No Passing Gear (forced detent) Upshifts Normal
- A/T - No Upshift/Governor Contamination
- A/T - 700R4 Solid Teflon Sealing Rings/Turbine Shaft
- A/T - Sprag Rotation
- A/T - Overdrive Bind Up When Engaged
- A/T - THM 2004R 700R4 TCC Stalls Engine In Drive/Reverse
- A/T - Checking Pressure Switches For Leaks
- A/T - 700R4 TCC Lock-Up Delay Valve
- A/T - Math Formulas Part I
- A/T - 700R4 Wiring Diagrams Thru 1989
- A/T - Twenty Steps To Successful Repairs
- A/T - 4L60/THM 700R4 200R4 Fluid Filter Seal
- A/T - Math Part II
- A/T - 700R4/200-4R New Fluid Filter Seal
- A/T - 700R4 Lubrication Update
- A/T - Choosing the Right ATF
- A/T - ATRATB8725 Service Bulletin Correction
- M/T - Noise With Automatic Overdrive Disengaged
- M/T - Neutral/Drive Gear Rattle
- Compact Disc Players - CD Changer Loading Procedures
- SIR - Operating Vehicle with Warning Light On
- A/T - Extension Housing Bushing Service
- Dealer Service Bulletin - Index
- Engine - Rough/Unstable/Incorrect Idle
- A/T - DEXRON III Fluid Introduction
- Recall 85V029000: Speed Control Defect
- Rear Tie Rods - Inspection
- Isolation Diodes - Replacement Information
- Coolant Sensor - Service Kit
- PROM/MEMCAL - Identification Marks
- Fuel - Rusting Filler Door Hinge Links/Pins
- Instrument Panel - Upper Surface Reflection
- Instrument Panel - Upper Surface Cleaning
- Suspension - Chassis Lubrication Importance
- Engine - Oil Level Operating Range
- Electrical - New Nickel Tape Shields Harnesses
- Fuels - Effect of Volatility on Driveability
- Fuel - How Fuel Economy Is Determined
- Cruise Control - Misdiagnosed Delay
- Cruise Control - Trouble Shooting Hints
- Engine - High/Rough or Unstable Idle
- Tires/Wheels - Wheel Weight Usage Precautions
- Roof Panel - Attaching Point Adjustment
- Transparent Removable Roof Panel - Breakage
- Seat - Rear Lap/Shoulder Belt Kits
- Body - Urethane Adhesives for Glass Applications
- Key Code - Information
- Paint - Acid Rain Damage to Base Coat/Clear Coat
- Paint - Basecoat/Clearcoat Repair Systems
- Paint - Exterior Colors Chart
- Paint - High Volume Low Pressure Paint Application
- Paint - Importance of Checking Clear Coat Thickness
- Paint - Repair Procedure Without Repainting
- Warranty - Rail Dust Removal & Chemical Spotting Labor
- Paint - Anti Chip Coatings
- Paint - Later Model Colors
- Carpet Inserts - Loose
- Electrical Connectors - Service Procedure
- A/T - Elimination of 4-3 Downshift Switch
- A/T Rear Case Bushing - Removal & Installation Procedure
- A/T - 4L60 Binding/Inoperative In Reverse
- A/T - Harsh 1st to 2nd Gear Upshift
- A/T - New Control Valve Assembly Elimination of TCC Bore
- A/T - Partial Tie Up In reverse
- A/T - Proper Usage of Spacer Plate Gaskets, Overhaul Kit
- A/T - New Control Valve Assembly Identification
- A/T - Evaluating Peened Spacer Plates
- A/T - 4L60/700-R4 Transmissions Stuck In First
- Drivetrain - Recommended Axle Lubricant
- A/T - New 2-4 Servo Cover and Seal
- Underhood Lamps - Inoperative or Stay On
- A/T - Accumulator Pistons & Seals Enhance Shift Points
- A/T - 1-2 Accumulator Piston/Outer Spring Replacement
- Turn Signal Lever - Rattles
- A/C - Use of Alternate Refrigerants In CFC 12
- Contaminated R12 Refrigerant - Testing & Handling
- A/C - Retrofitting R-12 Vehicles to R-134A
- A/T - THM 700-R4 New Input Housing and Shaft Assembly
- M/T - Reassembly Precaution Output Shaft & Pump Assembly
- M/T - Damage From Roll Pin Not Seated Fully
- A/T- THM 700-R4 New Output Shafts and Seal
- A/T - THM 700-R4 Checking Pinion Washer For Wear
- M/T - Loss of Overdrive Operation
- P/S - Reduced Assist When Cold
- Power Steering - Reduced Assist At Low Temperatures
- M/T - Maintenance Information
- Brakes, Front - Pulsation Diagnosis, Correction, Repair
- Power Seat Transmission - Usage and Identification
- Fuel - Reformulated/Oxygenated Gasolines
- Fuel - No Start, Driveability, Excessive Alcohol Content
- Fuel - Use of Gasoline Containing 15 Percent MTBE
- Alignment - The Importance of Four Wheel Alignment
- A/T - Grinding Noise In All Ranges/No Drive Condition
- Body - Metal Panel Adhesive Bonding Information
- Cooling System - Coolant Recycling Information
- M/T - Hydraulic Clutch Bleeding Procedure Improvement
- Engine, A/T - Shift/Driveability Concerns/MIL ON
- Instruments - Reduced PRNDL Display Visibility
- Body - Polypropylene Energy Absorber Replacement
- Engine - Sealant Usage/Procedures
- Electrical - Aftermarket Fuse Warning
- Wheels - Chrome Wheel Brake Dust Accumulation/Pitting
- Brakes - Rotor Lateral Runout Correction Information
- Restraints - Usage of Used/Salvaged/Imitation Components
- A/T - 4L60, Revised Sprag/Forward Clutch Hub
- Fuel System - E85 Fuel Usage Precaution
- A/T - No Movement in Drive or 3rd Gear
- Engine/Fuel System - Oil/Fuel Additive Information
- Cooling System, A/C - Aluminum Heater Cores/Radiators
- Wheels/Tires - Upsized Wheel/Tire Characteristics
- Audio System - Refurbishing Radio Faceplates/Knobs
- Body - Hem Flange Rust Repair Information
- Body - Marks/Stains on Windshield When Wet
- Wheels/Tires - Chrome/Steel Valve Stem Cap Precautions
- Engine - Noise/Damage Oil Filter Application Importance
- Engine - Drive Belt Misalignment Diagnostics
- Body - Maintaining Exterior Weatherstrip Appearance
- 06-08-111-004B - BULLETIN CANCELLATION NOTIFICATION
- Body - Stain/Film On Windshield Glass Perimeter
- Wheels/Tires - Accessory Wheel And Tire Information
- Wheels/Tires - Replacement Wheel Weight Information
- Tires/Wheels - Low Tire/Leaking Cast Aluminum Wheels
- Tires/Wheels - Tire Puncture Repair Procedures
- Lighting - Headlamp Warranty Replacement Guideline
- Interior - Proper Use of Floor Mats
- Wheels - Changing Procedures/Precautions
- Body - Squeeze Type Resistance Spot Welding/Equipment
- Electrical - Intermittent MIL/DTC P2138/Reduced Power
- Restraints - Extender Availability For Seat Belt
- Interior - Seat Cover Wrinkle/Crease/Burn Info
- A/T - Water Or Coolant Contamination Information
- Body - Drilling High Strength Steel Using CryoCobalt(R)
- Body - Vehicle Glass Distortion Information
- Fuel System - TOP TIER Detergent Gasoline (Canada)
- Tires/Wheels - Information on Tire Radial Force Variation (RFV)
- Engine - GM Dexos 1(R) And 2(R) Oil Specifications
- Engine - GM dexos 1(R) and dexos 2(R) Oil Specifications/Info.
- Drivetrain - Information on Driveline Clunk Noise
- Wheels - Chromed Aluminum Wheel Staining/Pitting/Corrosion
- Body - Paint-less Dent Repair Process
- Wipers/Washers - Windshield Wiper Performance Information
- Electrical - Ground Repair Information
- Interior - Cleaning Instrument Panel, Interior Trim
RENDER: 1.0x
Recommended Tools & Savings
Use the Manual With the Right Hardware
Pair factory procedures with proven DIY tools so the instructions are easier to execute.
Affiliate disclosure: We may earn a commission at no extra cost to you.
When to See a Mechanic
Stop DIY work and contact a certified mechanic immediately if any of the following apply:
- • You smell fuel, burning insulation, or see smoke.
- • Brakes feel soft, pull hard to one side, or make grinding noises.
- • The engine overheats, stalls repeatedly, or misfires under load.
- • You are missing required tools, torque specs, or safe lifting equipment.
- • You are not confident in the next step or safety outcome.